Order this document MBRP20030CTL/D POWERTAPII SWITCHMODEPower Rec

The Datasheet Archive - 100 Million Datasheets from 7500 Manufacturers.

Order this document MBRP20030CTL/D POWERTAPII SWITCHMODEPower Rec

Datasheet Thumbnail

Top Searches for this datasheet

Order this document MBRP20030CTL/D
POWERTAPII SWITCHMODEPower Rectifier
SWITCHMODE Power Rectifier uses Schottky Barrier principle with platinum barrier metal. This state-of-the-art device following features: Dual Diode Construction Paralleled Higher Current Output Guardring Stress Protection Forward Voltage Drop 150°C Operating Junction Temperature Recyclable Epoxy Guaranteed Reverse Avalanche Energy Capability Improved Mechanical Ratings
Mechanical Characteristics Case: Epoxy, Molded with metal heatsink base Weight: grams (approximately) Finish: External Surfaces Corrosion Resistant Terminal Torque: lb-in Base Plate Torques: procedure given Package Outline Section Shipped units foam Marking: B20030L
Product Preview
MBRP20030CTL
Motorola Preferred Device
SCHOTTKY BARRIER RECTIFIER AMPERES VOLTS
CASE 357C-03 POWERTAP
MAXIMUM RATINGS
Rating Peak Repetitive Reverse Voltage Working Peak Reverse Voltage Blocking Voltage Average Rectified Forward Current Rated 125°C Peak Repetitive Forward Current Rated Square Wave, kHz) 100°C Non-repetitive Peak Surge Current (Surge applied rated load conditions halfwave, single phase, Peak Repetitive Reverse Surge Current kHz) Storage Temperature Operating Junction Temperature Voltage Rate Change (Rated Device Symbol VRRM VRWM IF(AV) IFRM IFSM IRRM Tstg dv/dt Value Unit Volts
1500 +150 +150 10000
Amps Amps Amps V/µs
THERMAL CHARACTERISTICS
Thermal Resistance Junction Case 0.45 °C/W
ELECTRICAL CHARACTERISTICS
Maximum Instantaneous Forward Voltage Amps, 25°C) Amps, 25°C) Maximum Instantaneous Reverse Current (Rated Voltage, 25°C) Rating applies when surface mounted minimum size recommended. Pulse Test: Pulse Width Duty Cycle POWERTAP SWITCHMODE trademarks Motorola, Inc.
This document contains information product under development. Motorola reserves right change discontinue this product without notice. Preferred devices Motorola recommended choices future best overall value.
0.52 0.60
Volts
©RectifierInc. 1996 Data Motorola, Device
MBRP20030CTL
MAXIMUM MECHANICAL RATINGS
Terminal Penetration: Terminal Torque: Mounting Torque Outside Holes: Mounting Torque Center Hole: Seating Plane Flatness 0.235 25-40 in-lb 30-40 in-lb 8-10 in-lb (between mounting holes)
POWERTAP MECHANICAL DATA APPLIES OVER OPERATING TEMPERATURE
Vertical Pull lbs.
Lever Pull lbs.
Note: While POWERTAP capable sustaining these vertical levered tensions, intimate contact Note: between POWERTAP heat sink lost. This could lead thermal runaway. very Note: flexible leads recommended anode connections. thermal grease highly recommended.
MOUNTING PROCEDURE
POWERTAP package requires special mounting considerations because long longitudinal axis copper heat sink. important follow proper tightening sequence avoid warping heat sink, which reduce thermal contact between POWERTAP heat sink.
STEP Locate POWERTAP heat sink start mounting bolts into threads hand turns).
TURNS
TURNS
TURNS
POWER
HEAT
SINK
STEP Finger tighten center bolt. bolt catch threads heat sink important make sure face bolt washer contact with surface POWERTAP. STEP Tighten each bolts between in-lb.
TURNS
FINGER-TIGHT
TURNS
POWER
HEAT
SINK
IN-LB
FINGER-TIGHT
IN-LB
POWER
HEAT
SINK
STEP Tighten center bolt between in-lb.
IN-LB
IN-LB
IN-LB
POWER
HEAT
SINK
STEP Finally, tighten bolts between in-lb.
IN-LB
IN-LB
IN-LB
POWER
HEAT
SINK
Rectifier Device Data
MBRP20030CTL
PACKAGE DIMENSIONS
0.25 (0.010)
NOTES: DIMENSIONING TOLERANCING ANSI Y14.5M, 1982. CONTROLLING DIMENSION: INCH. TERMINAL PENETRATION: 5.97 (0.235) MAXIMUM. INCHES 3.450 3.635 0.700 0.810 0.615 0.640 0.120 0.130 0.435 0.445 1.370 1.380 0.007 0.030 1/4-20UNC-2B 0.270 0.285 31.50 0.600 0.630 0.330 0.375 0.170 0.190 MILLIMETERS 87.63 92.33 17.78 20.57 15.53 16.26 3.05 3.30 11.05 11.30 34.80 35.05 0.18 0.76 1/4-20UNC-2B 6.86 7.32 80.01 15.24 16.00 8.39 9.52 4.32 4.82
0.25 (0.010)
SEATING PLANE
CASE 357C-03 ISSUE
Rectifier Device Data
MBRP20030CTL
Motorola reserves right make changes without further notice products herein. Motorola makes warranty, representation guarantee regarding suitability products particular purpose, does Motorola assume liability arising application product circuit, specifically disclaims liability, including without limitation consequential incidental damages. "Typical" parameters which provided Motorola data sheets and/or specifications vary different applications actual performance vary over time. operating parameters, including "Typicals" must validated each customer application customer's technical experts. Motorola does convey license under patent rights rights others. Motorola products designed, intended, authorized components systems intended surgical implant into body, other applications intended support sustain life, other application which failure Motorola product could create situation where personal injury death occur. Should Buyer purchase Motorola products such unintended unauthorized application, Buyer shall indemnify hold Motorola officers, employees, subsidiaries, affiliates, distributors harmless against claims, costs, damages, expenses, reasonable attorney fees arising directly indirectly, claim personal injury death associated with such unintended unauthorized use, even such claim alleges that Motorola negligent regarding design manufacture part. Motorola registered trademarks Motorola, Inc. Motorola, Inc. Equal Opportunity/Affirmative Action Employer. Mfax trademark Motorola, Inc. reach EUROPE Locations Listed: Motorola Literature Distribution; P.O. 5405, Denver, Colorado 80217. 303-675-2140 1-800-441-2447 MfaxTM: RMFAX0@email.sps.mot.com TOUCHTONE 602-244-6609 INTERNET: http://Design-NET.com JAPAN: Nippon Motorola Ltd.; Tatsumi-SPD-JLDC, Seibu-Butsuryu-Center, 3-14-2 Tatsumi Koto-Ku, Tokyo 135, Japan. 81-3-3521-8315 ASIA/PACIFIC: Motorola Semiconductors H.K. Ltd.; Ping Industrial Park, Ting Road, N.T., Hong Kong. 852-26629298
MBRP20030CTL/D Rectifier Device Data

Order this document MBRP20030CTL/D POWERTAPII SWITCHMODEPower Rec

Top Searches for this datasheet

Other recent searches